|
Maintenance - Hoses
Hoses
All the hoses on the sprayer should
be inspected periodically for any signs of deterioration. Also check
for any signs of chafing, particularly around the areas of the height
mast where the boom goes up and down.
Damaged or perished pipes should be
replaced without delay. The consequences of a high pressure hose
bursting can be quite serious.
Parts
All replacement parts are available
from your dealer or T.J. Frazier Ltd. Some parts are fairly common
and may also be available from other local sources. If you require
any parts information please do not hesitate to contact either your
dealer or ourselves.
A parts manual will soon be
available on request.
When ordering parts please give us
as much information as possible including the following:
The model/build number - this is on
a plate on the front offside of the chassis e.g. 5D354
The sprayer model and serial
number, on a plate behind the main suction filter.
RDS automatic sprayer controllers
An RDS Delta 3 or 4 or Pro Series
automatic sprayer controller may be fitted to your Frazier sprayer as
optional equipment. If it is, you will find the main operating
instructions in an accompanying RDS manual.
Instructions on how to calibrate
the tractor unit wheel circumference, the engine tachometer and the
PTO tachometer can be found in the tractor unit manual.
The following notes on the RDS
automatic controller are specific to the Frazier sprayer and should
provide a further useful reference.
The flow meter is fitted into a
hose between the main electric on/off valve and the boom section
valves. The hoses can be quite easily disconnected from each end of
the flow meter for periodic cleaning.
Before attempting to use the RDS
the safety relief valve pressure must be set to approx. 2 bar (30
psi) above your target pressure. This pressures must be set when the
RDS valve is in the fully closed position.
There after the pressure is only
normally altered by depressing the + / - buttons on the head unit if
the head unit is in manual mode, or if the dash board rocker switch
is in manual mode, on the main sprayer control panel.
< 35 > |